|Home | About | Journals | Submit | Contact Us | Français|
Therapeutic efficacy of an “Indigenous vaccine” has been evaluated with respect to a commercial vaccine (Gudair, Spain), for the control of clinical Johne's disease (JD) in naturally infected goatherds. Seventy-one goats (JD positive) were randomly divided into 3 groups (“Bison”, “Gudair” and “Sham-immunized”). After vaccination, goats were monitored for physical condition, morbidity, mortality, body weights, shedding of M. paratuberculosis (MAP) in feces, internal condition and lesions, as well as humoral and cell-mediated immune responses for 210 days. Study showed marked overall improvement in physical condition of vaccinated goats and average body weight gain was significantly higher (P < .05) in “Bison” group as compared to “Sham-immunized” goats. Mortality due to JD was significantly (P < .05) lower in vaccinated groups than in “sham-immunized”. Morbidity rates (due to diarrhea and weakness) were lower in “Bison” group as compared to other groups. Died goats from vaccinated groups showed regression of gross JD lesions and regeneration of fat layer around visceral organs while “Sham-immunized” goats exhibited frank lesions. Vaccinated goats had higher protective CMI response and also higher antibody titer for the trial period as compared to “Sham immunized”. Both vaccines also reduced shedding of MAP in feces significantly (P < .05). Though the two vaccines effectively restricted the severity of clinical symptoms of JD, however “Indigenous vaccine” was superior in many respects.
Mycobacterium avium subspecies paratuberculosis (MAP) is the cause of chronic incurable infection of animals called Johne's disease (JD) and is also associated with Crohn's disease (CD) in human beings . MAP has wide host range and interspecies transmission has been reported frequently . JD causes huge economic losses by way of reduced productivity in domestic ruminants, all over the world. It is estimated that 68.0% of US dairy herds are infected with JD, costing $200 million to $1.5 billion per year to dairy industry . These losses have been neither estimated nor realized in most of the developing and poor countries. In animals vaccination is the only cost effective method for controlling JD. After the first description of a live attenuated vaccine in France , many of the developed countries resorted to vaccination and have effectively decreased JD prevalence in their herds and flocks [5–10]. Both killed and live attenuated vaccines have the same efficiency in small ruminants ; however, killed vaccine has many advantages in terms of safety, marketing, and storage . Vaccine prepared from field isolate worked better than “commercial vaccine” in calves .
Goatherds maintained at Central Institute for Research on Goats (CIRG), Makhdoom were endemic for JD [14–16]. Using “test-and-cull” policy for past 25 years, prevalence of JD could not be reduced. Contrarily the incidence and pathogenicity of MAP increased over the years [14, 15]. Native “S 5” strain of MAP  recovered from a terminally sick goat has been characterized as “Indian Bison type”  and is most prevalent genotype in India . This native “S 5” strain is highly pathogenic and is a newly evolved genotype as compared to MAP K10 strain [20, 21], therefore, used for the development of ELISA kit  and “Indigenous vaccine” for JD . This pilot study was the first randomized trial to know the efficacy of “Indigenous vaccine” in comparison to a “commercial vaccine” for the control of Johne's disease in clinically infected farm goatherds.
Institute (CIRG) is registered with Committee for the Purpose of Control and Supervision of Experimentation on Animals (CPCSEA), Government of India, and use of JD-infected goats was approved by the Institute Ethics Committee.
Seventy-one discarded ready to cull (stunted/weak/diarrheic) and naturally infected goats with clinical JD (positive in culture and ELISA) from the farm herds of CIRG were randomly divided into 3 groups: “Bison”, “Gudair” and “Sham immunized”, consisting of 29, 24, and 18 goats, respectively. This pilot trial to study the efficacy of “Indigenous vaccine” was truly random, with respect to age, sex, and breed, stage of disease, and body weights of goats. In each group, age of goats varied from 1 to 8.2 years (85.0% were between 2–4 years). Goats in 3 groups were maintained together under semiintensive system of management with 150 gr of concentrate per goat, irrespective of sex, age, body weight, and physiological status. Physically goats were weak and emaciated when transferred from different goats units at CIRG, and JD, being endemic in goats, was primarily responsible for poor health condition of goats [14, 15]. Skin was rough, hard, and dry, eyes were dull and depressed, body weights were below normal, and JD was major cause of morbidity, mortality, and culling of goats.
Two inactivated vaccines: “indigenous vaccine”  developed using novel, native, pathogenic, and genetically characterized “S 5” strain of MAP (Indian Bison type) of goat origin  and a “Commercial vaccine” (Gudair) manufactured by CZ Veterinaria, Spain  were compared for their therapeutic attributes (immune response and improvement in the health status) of naturally infected goats with clinical JD for a period of 210 days. “Indigenous vaccine”  contained 2.5mg (dried weight) of heat inactivated native strain of MAP  with 0.01% of Thiomersal suspended in Aluminum hydrooxide gel (CZ Veterinaria, Spain). Dry weight of 2.5 mg contained approximately 12 × 108 bacilli per mL (McFarland standard). “Commercial” vaccine contained 2.5mg of MAP bacilli (strain 316F) per mL of vaccine in mineral oil.
Goats in “Bison” group were vaccinated with 1mL of “indigenous vaccine” subcutaneously (behind the ear). Similarly “Gudair” group was vaccinated with 1mL of “Commercial vaccine” and “Sham-immunized” group was given 1mL of sterilized PBS.
Body weights of the goats were recorded, zero day post vaccination (DPV) and at 30DPV intervals up to 210 days. Average gain in body weights by goats of three groups was analyzed using ANOVA. Serum samples of all the goats and blood samples of 9 goats (3 from each group) were screened by ELISA and Lymphocyte Transformation Test (LTT), respectively. Nitric oxide (NO) estimation was performed on serum samples of all the goats at 30-day interval. Improvements in body condition, mortality, and morbidity were recorded. Goats that died during the trial period were subjected to detailed necropsy and lesions were recorded. Goats falling sick were treated symptomatically.
PBMCs were isolated as per method of Boyum , using Histopaque (Sigma-Aldrich).
LTT was performed as per Uma et al. , with modifications, on the representative goats (3 each) of the 3 groups (2 vaccinated and 1 Sham immunized) using PBMCs at 60DPV. Briefly, PBMCs isolated from goats of each group were stimulated in triplicate with mitogen Con A (Sigma) and sonicated protoplasmic antigen of MAP “Indian Bison Type” each at 20μg/mL concentration, and a set of PBMCs of the same goat was kept as unstimulated control. PBMCs were cultured in 96-well tissue culture plates at 37°C at 5% CO2 for 120 hours (5 days). At the end of 120 hours MTT assay was performed and 25μl of MTT [3-(4, 5- dimethyl trizol-2-yl)-2, 5-diphenyl tetrazolium bromide] dye (5mg/mL) was added to each well of the tissue culture plate. Plate was incubated at 37°C for 4 hours. After incubation 150μl of DMSO (dimethyl sulfoxide) was added to each well and incubated overnight at 37°C and absorbance was read at 570nm. Proliferation of lymphocytes was indicated by optical density value of the well with test samples and that of the unpulsed wells. For analysis of data, a signal-to-noise ratio, that is, Stimulative Index (SI) was calculated for individual goats using the following formula: Average OD at 570nm in stimulated wells/Average OD at 570nm in nonstimulated control wells. Average SI value for each group of goats was calculated and compared to assess cellular immune response in vaccinated and sham-immunized groups at 60DPV.
Pre- and post-vaccination antibody response was measured by ELISA. Antibody titers were monitored in all the goats from zero to 210DPV at 30-day interval as per Singh et al. . OD values of serum samples were transformed to S/P ratio as described by Collins  and goats in strong positive category were considered as positive.
Nitric Oxide was estimated at 0, 15, 45, 90 and each 30DPV after 90 days up to 210DPV in the serum samples as per Sastry et al. . Optical density (OD) values were transformed into OD index values by division of the mean OD for each serum by the mean OD for the positive control.
Fecal culture was performed on zero and 210 DPV from all the goats to check the efficiency of two vaccines in decreasing number of MAP shedders. Fecal samples were grounded, centrifuged, as well as decontaminated (0.9% HPC), and sediment was inoculated on Herrold's egg yolk medium with mycobactin J as per Merkal .
There was marked improvement in the overall body conditions of vaccinated goats as compared to sham immunized. Vaccinated and Sham-immunized goats could be easily differentiated from distance on the basis of differences in the body conditions. Vaccinated goats were alert, active, healthy, regained skin luster, shining, pliability, regeneration of hairs and had shining bright eyes.
Average body weights, at the time of vaccination in 3 groups, were almost similar (Table 1). At the 210DPV there was significant difference in the average body weights gained by the goats of vaccinated groups than in sham-immunized group. Goats in “Bison” group gained higher body weights as compared to “Gudair” (P > .05) and “sham-immunized” (P < .05) groups. Few goats from each group lost weight (in comparison to weight at zero DPV) during the trial period. Percentage of goats loosing body weight was higher in sham-immunized (38.9%) followed by Gudair (33.3%) and Bison (17.2%) groups. Lowered number of vaccinated goats that lost weight after vaccination was indicative of the maximum “individual effect” of the “Indigenous vaccine”.
Overall mortality rate was lower in vaccinated groups than in “Sham-immunized” group (Table 2). Percent of goats that died due to JD were 71.4%, 14.2%, and 16.6% in “sham-immunized”, “Gudair”, and “Bison” groups, respectively. On comparing the mortality due to JD between zero and 210 DPV, there were significantly less (X 2 = 6.28, df = 1, P < .02) deaths in the vaccinated groups than in sham-immunized goats.
There was minor outbreak of contagious ecthyma (Orf) in 12 vaccinated goats just after vaccination and lasted for 7 days. In “Bison” group, one goat of Marwari breed suffered from maggotic wound and was under treatment for 22 days. There was significant decrease in the body weight of this goat. In “sham-immunized” group besides diarrhea, pneumonia was frequent cause of sickness. Number of goats sick (due to diarrhea and weakness) and those that received treatment during trial period were higher in sham-immunized group as compared to vaccinated groups.
Four goats, out of 7 died in “Sham-immunized group”, had marked gross lesions of JD, and typical acid fast bacilli indistinguishable from MAP were demonstrated in impression smears. Whereas, 2 goats that died at 60 DPV in “Gudair” group showed mildre inflammatory lesions in mesenteric lymph nodes (reduced thickening and size, lowered level of inflammation) and intestines (lowered thickening and no corrugations). Substantial fat layer was generation around all the visceral organs as compared to goats that died in sham-immunized group. Similarly, in “Bison” group also gross lesions of JD were mild in goats that died within few months of vaccination. Marked improvements were seen in the internal condition of one goat of “Bison” group that died at 165DPV. Wherein gross lesions for JD were very mild, carcass yield was average and there was extensive regeneration of fat layer (visceral fat, kidney fat, cod fat, fat on genital organs, etc.) around all the visceral organs in comparison to sham-immunized goats (Figure 1). This goat died of acidosis.
Ability of the PBMCs to recognize and respond to MAP antigen was investigated. PBMCs of vaccinated groups had greater, “Stimulative Index” (SI), when pulsed with protoplasmic antigen from native MAP strain than “Sham-immunized” group at 60DPV (Figure 2). However, SI was higher in “Bison” as compared to “Gudair” group. Proliferation of cells in response to mitogen was higher as compared to stimulation with MAP in all the three groups.
Results of nitric oxide (NO) production were expressed as geometric means at each sampling interval and are graphically presented in Figure 3. At 0DPV, concentration of NO in serum was comparable among the 3 groups, but afterwards vaccinated group of goats had higher NO concentration than “sham immunized” (Figure 3). At 45DPV and onward sampling intervals, both of the vaccinated groups had significantly higher (P < .05) concentration of NO as compared to “sham-immunized” group. In “Bison” and “Gudair” groups, peak NO concentration was seen at 45DPV and subsequently concentration declined slightly at 90DPV. After 90DPV at each sampling interval, goats in vaccinated groups maintained NO concentration with slight up and down and remained higher than sham-immunized goats at all the postvaccination intervals.
After vaccination high seroconversion rates were seen in vaccinated goats as compared to “Sham-immunized” (Figure 4). Number of goats were positive in ELISA test at the time of vaccination (0DPV), since the trial was conducted on discarded goats with advanced stage of MAP infection. However, percent goats seroconverted remained higher in vaccinated groups than in “Sham-immunized” group at all the postvaccination sampling intervals. Almost all the goats in vaccinated groups became seropositive (seroconverted) at 150DPV (Figure 3).
Fecal culture of goats in 3 groups was performed at zero and 210DPV. Percent of goats positive for MAP at 0 day were 88.8, 79.3, and 79.1 in “sham-immunized”, “Bison”, and “Gudair” groups, respectively. At 210DPV there was significant reduction in shedding of MAP (Bison: X 2 = 4.293, P = .038; Gudair: X 2 = 3.938, P = .047) in feces of goats in “Bison” and “Gudair” groups. Two vaccines reduced shedding of MAP in feces dramatically and only 17.2 and 29.1% goats were excreting MAP in “Bison” and “Gudair” groups, respectively, at 210DPV. In “sham-immunized” group, all the goats (18 = 100%) were positive for excretion of MAP at 210DPV.
Vaccination has been known to offer good protection and recovery against MAP infection and shown to reduce the prevalence of clinical JD by 90% and prevalence of JD in herds by about 50% . First Indian “Indigenous vaccine” against JD in goats  was developed using most prevalent and highly pathogenic “S 5” strain of Mycobacterium avium subspecies paratuberculosis (MAP) genotyped as “Indian Bison Type”. This “indigenous vaccine” has been shown to provide good protection (prophylactic) in experimentally vaccinated and twice-challenged goats . There are a number of reports on the prophylactic properties of JD vaccine, whereas very few reports are available on the therapeutic potential. Substantial reports exist on the significant reduction in mortality, clinical symptoms, and excretion of MAP bacilli in feces after vaccination of infected goats, thereby reducing environmental contamination and providing less opportunity for disease transmission.
Sigurdsson and Gunnarson  achieved successful eradication of JD in Iceland by vaccinating lambs once with killed vaccine. Similar results were reported by Crowther et al.  in sheep in Cyprus by vaccinating all stocks with live attenuated vaccine. Similarly in Norway, after several years of unsuccessful efforts to eradicate JD in goats (isolation and slaughter), vaccination program with “live attenuated vaccine” for kids was started in 1967 and the infection of MAP was reduced from 53% to 1% . In 1964, Great Britain introduced a scheme for the voluntary vaccination of the stock on infected farms and freedom from clinical disease was achieved after an average of 4 years . In 1983, a control program based on killed vaccine was initiated in The Netherlands and this strategy has been successful in reducing clinical JD and was less expensive than subsidized cull and slaughter program .
Results of the present study also indicated that vaccination could be practiced in any stage of disease (sub-clinical, clinical, and advance clinical), in any age group (kids above 3 months old to adults) and in any physiological stage (dry, lactating, or pregnant). Initial priming of the goats with MAP infection at the start of trial could have elicited higher immune response against vaccine (second inoculation of the antigen). JD was endemic in CIRG herds; therefore, continuous and slow reinfection of vaccinated animals from environment might have booster effect, thereby complete turnaround in the condition of ready to cull goats when trial was started. Incomplete degree of the response in 15-day-old kids as observed by Corpa et al.  might be due to immature immune system at that age. JD vaccination has been practiced during first weeks of life on the basis that the protection would be conferred for the first contact with mycobacteria [30, 33]. However, other studies on vaccination of adult animals also showed very good results in controlling JD [6, 9]. Corpa et al.  also showed that immune response was higher in adult animals as compared to few weeks old animals.
Lymphoproliferative response to antigen stimulation has been widely used as in vitro correlates of cell-mediated immunity . PBMCs from vaccinated and “sham-immunized” goats were used to assess the response to protoplasmic antigen of MAP. Proliferative response was higher in PBMCs from vaccinated groups on stimulation with MAP antigen than in PBMCs from “sham-immunized” group. However, stimulative index was higher in PBMCs from “Bison” than in “Gudair” group. Low responsiveness may be attributed to the suppressive factors secreted by monocytes and lymphocytes . Another possibility may be a shift from Th l to Th 2 type of cytokine response . Further preferential sequestration of antigen-specific T cells into the infected areas leads to their absence in peripheral blood .
It is generally believed that reactive nitrogens, such as NO, are most effective in direct killing of mycobacteria . Significantly higher NO concentration was seen in vaccinated groups (maximum in “Bison” group and least for “sham-immunized” group). Increased production of NO induced by antigen may cause effective immune response towards MAP and may lead to inhibition of MAP in macrophages.
Significant rise in the peripheral blood antibodies was seen in vaccinated groups after vaccination and “peak titers” were attained at 60DPV that gradually declined, such pattern was absent in “sham-immunized” group. Comparative antibody titers, in the vaccinated groups, were higher in “Bison” group. In vaccination of sheep by a killed vaccine maximum ELISA reactors were observed around 30DPV . In a study, 13 of the 15 vaccinated calves also became ELISA positive within 60 to 360DPV . In some goats of vaccinated group there was again rise in the antibody titer at 180DPV. But this rise in the antibody titer was less than the primary maxima observed at 60DPV. Although antibody response may not have the protective effect, it would be an indicator of the degree of the activation of immune system against mycobacteria . Th1 and Th2 responses are not antagonist and IFNγ can play stimulatory effect on B-lymphocytes and antibody production . Antibody titers were higher in few goats of “sham-immunized” group but titers were low as compared to vaccinated groups.
There was decreasing trend of NO concentration in “sham-immunized” goats. Probably protective Th1 response decreased due to decrease in the concentration of pro-inflammatory cytokines (IFNγ, IL-12, IL-2, TNFα, etc.). Though NO concentration also showed decreasing trend in vaccinated goats, they still maintained significantly higher concentration of NO as compared to “sham-immunized” goats. These results were further supported by antibody results, in “sham-immunized” goats, where titers increased slightly towards the end of the experiment. As “‘sham-immunized” goats approached terminal stage of JD, inhibitory Th2 responses might be increased with suppressed activity of antiinflammatory cytokines to limit the host tissue damage.
Necropsy of goats from “sham-immunized” group exhibited marked gross lesions of JD. Lymph nodes were highly enlarged and swollen, intestinal mucosa was thickened with prominent ridges (corrugation), and degeneration of visceral fat was marked in these goats. Goats from vaccinated groups did not show severe lesion of JD grossly due to remission of lesions after vaccination. In a study of vaccination in infected animals, Corpa et al.  also reported reduction in progression of granulomatous lesions and in bacterial shedding. Similarly, Juste et al.  also noticed regressive type granulomas (tuberculoid forms of lesions) located exclusively in the intestinal organized lymphoid tissues in vaccinated animals, whereas in nonvaccinated animals lesions spread to other areas of intestine causing severe enteritis. Therefore, vaccination may have potential to direct the inflammatory cascade into a beneficial mode.
Vaccination reduced fecal shedding in significant number of vaccinated goats. Initially, 16 (88.8%) goats were positive in “sham-immunized” group, but at 210DPV all the goats were positive in fecal culture. At zero and 210DPV, the number of goats excreting MAP decreased from 23 (79.3%) and 19 (79.1%) to 5 (17.2%) and 7 (29.1%) in “Bison” and “Gudair” groups, respectively. Number of goats negative for MAP infection were more in “Bison” group. Colony-forming units (cfu) counts also decreased in vaccinated goats as compared to 0 DPV. However, in “sham-immunized” group, cfu increased in 55.0% of goats.
Vaccination of lambs against ovine JD reduced deaths up to 90% and also reduced amount of bacilli passed in feces by up to 90% . Rapid decrease in new clinical cases was achieved following immunization of infected adult sheep flocks having severe clinical disease . Similar results have been reported by Uzonna et al. , where vaccine prepared from field isolate reduced the number of fecal shedders more than that of commercial vaccine.
Present trial indicated that “Indigenous vaccine” used in this study exhibited “Therapeutic effect” by reversing the clinical signs. There was reduction in shedding of number of MAP bacilli per goat, number of goats with clinical, JD and number of goats positive bacteriologically (fecal shedders), and complete turnaround was visible in the physical condition of the vaccinated goats as compared to “sham immunized”. Internally the lesions of JD reduced and there was regeneration of visceral fat layer and fat layer around all the visceral organs. Goat became alert active, and udders were filled with milk despite continuous suckling by kids. “Indigenous vaccine” using aluminum hydrooxide gel as adjuvant was superior to “Gudair” using mineral oil, in controlling JD in the naturally infected goats. However, these minor differences in vaccine-induced immune response may have resulted due to use of two different adjuvants, differences in the genetic makeup of individual animals and level of MAP infection.
Single dose of “Indigenous vaccine” developed from highly pathogenic locally isolated “Indian Bison Type” genotype of MAP significantly reduced morbidity and mortality, reversed clinical signs as well as reduced shedding of MAP, and there was marked improvement in physical and internal body condition (Therapeutic effect). Therefore, “Indigenous vaccine” worked as “Therapeutic Vaccine” in goats suffering from clinical to advance clinical symptoms of JD.
Authors are thankful to Director, CIRG, for extending necessary facilities for the work and DSIR, New Delhi for providing financial assistance.